Daewoo Nexia

Since 1994 of release

Repair and car operation



Daewoo Nexia
+ The maintenance instruction
- Maintenance service
   1.2. The general instructions on repair
   1.2. Identification number of the car
   1.3. Car lifting
   1.4. Car maintenance service
   + 1.5. Control surveys and the servicing, spent by the owner
   1.6. The moments of an inhaling of carving connections
   1.7. Characteristics of the car with system of multidot injection of fuel
   1.8. Characteristics of cars (2 top camshafts of the engine)
   1.9. The sizes and weight of cars
+ The engine
+ 3. The engine (two top camshafts)
+ Cooling system
+ Топлевная and exhaust systems
+ Electric chain
+ 7. Ignition system
+ 8. The electronic block of management and gauges
+ Transmission
+ 10. A five-speed transmission and the main transfer RPO MM5
+ 11. Automatic Transmission
+ Steering
+ Running gear
+ 14. A forward suspension bracket
+ 15. A drive of forward wheels
+ 16. A back suspension bracket
+ Brake system
+ Body
+ Heating, ventilation
+ Electric equipment



1.4. Car maintenance service

1.4.1. A normal mode of operation of the car
THE GENERAL DATA

Shift of wheels


The regulations of servicing resulted more low (see the table), the including list of works and periodicity of their carrying out, are focused on conditions of normal operation of the car according to its appointment:

– Transportation of passengers and cargoes with observance of restrictions on loading and the recommended pressure of air in the tyres resulted on the tablet which is pasted at an end face of a driver's door;
– Operation on roads with enough high quality of a covering within admissible restrictions on movement modes.

Explanatories to the maintenance service table


All works on the maintenance service, resulted in the table, are in detail described more low in a management. At carrying out of the next servicing before the beginning of operation of the car be convinced that all preliminary removed details and knots are again established on the car and all necessary repair work is spent. Use only the recommended oils and operational liquids.

Check of belts of a drive of units

Examine a belt of a drive of the generator, the pump of the steering amplifier and the compressor of the conditioner of air. In the presence of signs of deterioration or damages (cracks, stratifications etc.) replace a belt. Adjust a belt tension.

Replacement of engine oil and the oil filter

Always use engine oil of a degree of quality not more low SG or ССМС G4/G5. Engine oils with designation SG possess higher operational properties in comparison with oils of degree of quality SF/СС or SF/CD. In marks of oil designation SG can meet as separately, and in combinations SG/СС, SG/CD.

Viscosity of engine oil

Viscosity of engine oil influences fuel profitability of the car and starting properties of the engine in cold weather. Less viscous oil improves fuel profitability and facilitates engine start-up at low temperatures. However at an air heat lubricant properties маловязкого engine oil worsen and more viscous engine oil is required. Engine operation on not recommended engine oils can lead to fast deterioration of details and an engine exit out of operation.

Service of system of cooling of the engine

Merge, wash out system of cooling and fill in a new cooling liquid.

Replacement of the fuel filter

Replace the fuel filter through each 45 Open Companies of km of run of the car. The filter is located on the right side under the Body of the car about a fuel tank.

Replacement of a filtering element of an air cleaner

Replace filtering element through each 30 000 km of run of the car. At operation of the car in the conditions of a strong dust content of air replacement of a filtering element should be made more often.

Fastening of the case throttle заслонки

Check up an inhaling of fixing bolts. If necessary tighten bolts динамоментрическим a key (the moment of an inhaling of 17 Nanometers).

Replacement of spark plugs

Replace spark plugs new the same type.

Type: the EXPERT Round R45ХLS.

Backlash: 0,7–0,8 mm (Engine DONS) or 1,0–1,1 mm (Engine SONS).

Check of wires of a high voltage

Clear wires and check up serviceability of isolation. Check up protective caps of wires on a cover of the distributor and the ignition coil. If necessary replace faulty wires.

Service of brake system

Check a condition brake колодок disk and drum-type brake mechanisms through each 15 000 km of run of the car or time in 12 months. Carefully measure a thickness of overlays brake колодок. If the residual thickness of brake overlays is insufficient for normal work of brake mechanisms before following servicing of the car (through 15 000 km), replace Pads or overlays with the new. Check up and if necessary clean an aperture сапуна in a cover of a tank of the main brake cylinder.

Transmission service

Transmissionnoe oil of a transmission with manual switching does not demand replacement during all term of operation. Oil in an automatic transmission and the oil filter are subject to replacement through each 75 000 km of run or 60 months, depending on that will come faster.

Check of a condition of tyres and wheels, shift of wheels

Check up a condition of tyres and presence of signs of abnormal deterioration or damages. For prolongation of service life of the complete set of tyres periodically rearrange wheels according to resulted on fig. Shift of wheels by the scheme. At non-uniform and fast deterioration of protectors of tyres check up corners of installation of wheels. Besides, check up serviceability of wheels. After dismantle of wheels from the car check up a condition of brake system according to point instructions "Check of a condition of brake system" of subsection "At each replacement of oil".
THE LIST OF WORKS Run or the operation period, depending on that comes faster
Run, thousand in km
1
15
30
45
60
75
90
105
120
The period, month
12
24
36
48
60
72
84
96
Belts of a drive of units (the generator, the pump of the steering amplifier)  
ABOUT
ABOUT
ABOUT
ABOUT
З
ABOUT
ABOUT
ABOUT
З
Engine oil and the oil filter of the engine (1), (3)  
ABOUT
З
З
З
З
З
З
З
З
System of cooling and connection of flexible pipelines  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Cooling liquid (3)  
ABOUT
ABOUT
ABOUT
З
ABOUT
ABOUT
З
ABOUT
ABOUT
The fuel filter  
З
З
Fuel pipelines and connections  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Filtering element of an air cleaner (2)  
ABOUT
З
ABOUT
З
ABOUT
З
ABOUT
З
The ignition moment  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Spark plugs  
ABOUT
З
ABOUT
З
ABOUT
З
ABOUT
З
Cover and rotor of the distributor of ignition  
ABOUT
ABOUT
ABOUT
ABOUT
Coal absorber and pipelines of tap of steams of fuel  
ABOUT
ABOUT
Valve RSV of compulsory ventilation картера the engine  
ABOUT
ABOUT
ABOUT
ABOUT
Gear belt of a drive of a camshaft  
ABOUT
З
ABOUT
З
The final pipeline and knots of fastenings  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Brake liquid (3)  
ABOUT
ABOUT
З
ABOUT
З
ABOUT
З
ABOUT
З
Drum-type brake mechanisms of back wheels (5)  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Disk brake mechanisms of forward wheels (5)  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Lay brake  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Pipelines of brake system and their connection, the brake amplifier  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Bearings of naves of back wheels  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Transmissionnoe oil in a transmission with manual switching (3)  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Free wheeling of a pedal of coupling and brake  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Liquid of a hydrodrive of coupling (3)  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Transmissionnoe oil in an automatic transmission (3)  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
З
ABOUT
ABOUT
ABOUT
Carving connections of knots of the chassis  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Tyres and pressure of air in tyres  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Corners of installation of wheels (4)  
To check up at abnormal deterioration of tyres, car withdrawal etc.
Steering wheel and steering drive  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Liquid and pipelines of the steering amplifier (3)  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Protective covers of hinges of semiaxes  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Seat belts, locks and buckles, fastening knots  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Locks, loops навески doors, hinges, latches of details of the Body  
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
ABOUT
Designations:
About – survey, check and definition of a technical condition. If necessary to finish level to norm or to make clearing, adjustment, a tightening of fastenings
3 – replacement
(1) At car operation in adverse conditions (frequent trips on short distances, long work of the engine idling, a strong dust content of air) it is necessary to make engine oil replacement through 7500 km or each 6 months depending on that will come faster.
(2) At operation of the car in the conditions of a strong dust content of air replacement of a filtering element should be made more often.
(3) Applied operational materials are resulted in subsection "Replacement of engine oil and the oil filter".
(4) If necessary отбалансировать wheels.
(5) Intervals between servicings should be reduced at car operation in adverse conditions: frequent trips on short distances, long work of the engine idling, frequent driving in street stoppers, a strong dust content of air.